Australia's largest stock trading and investment forum Australia's #1 stock forum

Why renewables can't save the planet., page-236

First 236 Last

Share
Profile

Follow
mudguts

12,095 Posts.

477

22/01/20

08:42

Post #: 42505252
Share

Originally posted by birdman29 ↑

Assessing metal leaching from PV modules dumped in landfill

An Indian research team has analyzed around 300 scientific studies about PV panel waste containing carcinogenic metals. The researchers said solar module recycling is not economically profitable and policy support is necessary to avoid panels being dumped in landfill.

DECEMBER 4, 2019

Failed modules, stripped of their frames for recycling, destined for landfill in Australia. IRENA estimates there could be as much 78 million tons of PV waste to be dealt with by 2050.

Researchers at the department of civil engineering of the Indian Institute of Technology have reviewed around 300 studies concerned with carcinogenic waste in PV panels published between 2000 and 2018.In the study Initial metal contents and leaching rate constants of metals leached from end-of-life solar photovoltaic waste: An integrative literature review and analysis, published on the ScienceDirect website, the scientists say not enough attention has been paid to the leaching of metals from PV modules dumped in landfills. The team stated only 2.39% of 85 studies chosen for content analysis considered the issue.The researchers scrutinized literature about the metal contents of commercially available crystalline silicon, CIGS and CdTE thin-film products and amorphous silicon modules. Their study excluded the contents of frame and mounting materials, encapsulants, back sheets, junction boxes, copper wires, EVA and glass.
In crystalline silicon technology, aluminum and silicon contribute the major share in terms of weight, followed by copper, iron and zinc. “Maximum concentration of metal-of-concern lead was observed to be 4.02 mg/PV panel, or 0.689% in a typical crystalline Si-PV [module]” wrote the research team.
For CIGS thin-film devices, aluminum, copper and selenium were the most abundant materials while gallium – which is said to have apoptotic (cell-fatal) and carcinogenic properties if present in compound form – was found to make up 2.4% of the metal composition, with indium having a 13.14% share.In CdtE modules, copper, tellurium and cadmium had the largest concentration of metals. “Cd [cadmium] and Cu [copper] have been shown to be highly toxic for aquatic organisms,” states the study. “Cd metalloid is a known carcinogen that has a stringent maximum contaminant level (MCL) of 0.003 mg/l in drinking water.”EU exampleIn amorphous PV modules, aluminum (20.80%), iron (3.32%), silicon (1.45%) and copper (0.502%) were identified as the metals with the largest initial concentration. “However, there have been [fewer] studies for a-PV [amorphous PV] as their market shares have been observed to decline in previous years,” the study noted.The research team calculated 0.001-19.84% of dumped module weight was made up of cadmium, with lead supplying 0.0001-5.02%, and said the wide degree of variation in both figures indicated the need for further study.The authors of the paper cited the waste electrical and electronic equipment directive introduced by the European Union as an example other countries should follow to define new policies for the management of PV waste. Otherwise, stated the researchers, the lack of economic value in recycling such products at present is likely to see significant volumes dumped in landfill.
Threat to health

The presence of hazardous heavy metals such as the cadmium, tellurium, indium and gallium used in thin-film products would represent a significant threat to health and the environment if not disposed of correctly, added the paper.The lack of a comprehensive dataset for initial metal concentrations and of leaching studies under landfill conditions represented further gaps in knowledge which need to be addressed, according to the researchers.

Expand

I think that science is pretty settled.
1 Upvote

Reply

Top Stories

NIM

Nimy to raise $1.21M to explore 'newsy' WA targets

BHP

BHP dips as WA nickel suspended after A$6B hit; losses eased by US CPI and forewarning

MDI

Nanocap Middle Island Resources kicks off Barkly copper-gold drill run – a potential IOCG-style NT project

I88

Infini soars 50% as company reveals it could’ve just made uranium history – redefining what it means to be “high grade”

Week 27 Wrap: ASX hits all time high; CBA shares' two realities; US inflation hits 3% ahead of China plenum

SKS

SKS Technologies wins US$90M award to supply power to international hyperscale data centre in Melbourne

IMM

Immutep reports strong response rate from immunotherapies treating carcinomas

Bitcoin investors need to know the risks

AII

Almonty locks in govt agreement for tungsten oxide plant in South Korea

ASX hits all time high out the gate on Friday trades following bullish US inflation data

There are more pages in this discussion • 6 more messages in this thread...

First 236 Last