mt carbine, page-2

LEAD IS DENSE and ductile, has a low melting point, and is inexpensive, making it long prized for molding into ammunition. But it's also toxic to birds and other animals that ingest bullets and bullet fragments.

To address the need for less toxic ammunition with the same performance as lead bullets, researchers at Oak Ridge National Laboratory have now developed bullets made from a tungsten-tin composite material. ORNL has licensed the technology to WolfTech Manufacturing, Wakeman, Ohio, and the first bullets will be distributed by MDM Muzzleloaders, Maidstone, Vt.

Lead shotgun pellets for waterfowl hunting were banned nationwide in 1991 to prevent poisoning birds. In October, California banned lead ammunition for deer hunting in condor territory. Added restrictions on lead ammo are on the horizon in Missouri as well as other states.

The new bullets are made by compressing a mixture of coarse tin and tungsten powders at about 100,000 psi, under which the tin cold-welds to yield "chunks of tungsten in a sea of tin," says Richard A. Lowden, a senior research engineer at ORNL.

The grain size of the powders is critical: The tungsten particles must be small enough to distribute uniformly for a balanced bullet but large enough that they won't dissolve and create an environmental hazard. The tin particles can't be too small either, because they oxidize when exposed to air. Smaller particles have more surface oxide, which prevents bonding of the matrix. In the end, the optimal grain sizes are about 55 ìm diameter for tungsten and 100 ìm diameter for tin.

The composition that best mimics lead is 57% tungsten and 43% tin by weight. Compared with lead-free copper bullets, the tungsten-tin composites are heavier, enabling longer, straighter flight.

Used tungsten-tin bullets can be collected from shooting ranges and recycled. The low melting point of tin relative to tungsten means that the bullets can be melted, the tin poured off and repowdered, and the tungsten filtered and reused.

The properties of tungsten-tin bullets mimic those of traditional lead ammunition.


Courtesy of ORNL